PDA

View Full Version : Influences on Spark Plug Temp and Performance:



merc
10-11-2004, 06:00 PM
In the last two years we have learned many new things about our car and discussed it's merits. Spark plugs have been reviewed by several members. I spent a couple weeks reviewing posts on this site and others. I found some information that became helpful for me to understand the influences that make Spark plugs perform, and I attached this information in this tread. In the end I picked The NKG TR55IX part number 7164. The total cost including state tax was 53.00 for 8 plugs. This is 6.625 dollars per plugs. I purchased them through a local dealer named Advance Auto parts. They don't normally stock this part but I was able to order them from their Pittsburg warehouse in two days. My initial observations was a smoother idle and slightly better throttle response. I don't have a more accurate method of measuring such small performance gains. Denso plugs were a little pricier then I budgeted for this upgrade. I don't want to discount anyone’s personal history or vendor alliance. I am attempting to contribute a slightly different facet to this discussion.

We have talked a lot about performance from a tuning. Correct me if I am wrong, but the major differences I see from tuning is Timing and Air/Fuel. Although the Superchips software allows for several hundred tweaks, Timing and A/F are in the top 5. One of my many questions concerning this issue is what is the expectable range for the Marauder and the long-term effects of high timing settings to statistically displaying higher numbers.
What is safe and what is dangerous? Most people on this site don’t know what the performance chips or tuners performance setting are. They display a dyno number but don’t have a clue what adjustments were make to achieve these gains.



Below is a list of possible external influences on a spark plug's operating temperatures. The following symptoms or conditions may have an affect on the actual temperature of the spark plug. The spark plug cannot create these conditions, but it must be able to deal with all the levels of heat, otherwise performance will suffer and engine damage can occur:

Air/Fuel Mixtures seriously affect engine performance and spark plug temps.
• Rich air/fuel mixtures cause tip temperature to drop, causing fouling and poor drivability.
• Lean air/fuel mixtures cause plug tip and cylinder temperatures to increase resulting in pre-ignition, detonation, and possibly serious spark plug and internal engine damage.
• It is important to read spark plugs many times during the tuning process to achieve optimum air/fuel mixture. Computer-controlled engine applications do a pretty good job of this with the various sensors that report back to the ECM.

Higher Compression Ratios and Forced Induction will elevate spark plug tip and in-cylinder temperatures.
• Compression can be increased by performing any one of the following modifications:
? a) reducing combustion chamber volume (i.e.: domed pistons, smaller chamber heads, milling heads, etc.)
? b) adding forced induction (Nitrous, Turbocharging, Supercharging)
? c) camshaft change
• As compression increases, a colder heat range plug is required, as well as higher octane fuel and paying careful attention to ignition timing and air/fuel ratios are also necessary.

Advanced Ignition Timing: Advancing timing by 10° causes plug temperature to increase by approximately 70°C to 100°C.

Engine Speed and Load: Increases in firing-end temperatures and are proportional to engine speed and load. When traveling at a constant high rate of speed, or carrying/pushing very heavy loads, a colder heat range spark plug should be installed.

The heavier your vehicle or greater the amount of work the engine sees (racing applications, construction trucks, vans, RVs & Motorhomes, etc.), the more critical this becomes.

Ambient Air Temperature:

• As air temperature falls, air density volume increases, resulting in leaner air/fuel mixtures. This creates higher cylinder pressures and temperatures that causes an an increase in the spark plug's tip temperature. Fuel delivery should be increased.
• As temperature increases, air density decreases, as does intake volume, and fuel delivery should be decreased.

Humidity: As humidity increases, air volume decreases. The result is lower combustion pressures and temperatures, causing a decrease in the spark plug's temperature and a reduction in available power. Air/Fuel mixture should be leaner, depending on ambient air temperature.

Barometric Pressure and Altitude:

• Affects the spark plug's temperature
• The higher the altitude, the lower the cylinder pressure becomes. As the cylinder temperature decreases, so does the tip temperature.
• Many tuners attempt to "chase" tuning by changing spark plug heat ranges.
• The real answer is to play with the jetting or air/fuel mixtures in an effort to put more air back in the engine.

Smokie
10-11-2004, 06:34 PM
How do cams change the compression ratio ?

merc
10-11-2004, 06:39 PM
All performance camshafts close the intake valve 50 to 60 degrees or more after bottom dead center (ABDC). The longer the duration of the camshaft, the later the intake valve closes. It should also be obvious that the engine cannot begin making cylinder pressure until the intake valve closes. Therefore, the distance that the piston travels up the cylinder at 60 degrees ABDC versus 52 degrees ABDC reduces the volume of the cylinder, reducing the cranking pressure. I hope this answers your question Smoke.

Fast4Door
10-11-2004, 06:42 PM
How do cams change the compression ratio ?

They don't change the mechanical compression ratio, it's more like the "effective" compression ratio. The cam controls when in the compression stroke the compression actually starts.

As an example: Say your long duration cam keeps the intake valve open WAY past bottom dead center (common in a high RPM cam). The piston will be some ways up the cylinder before it actually starts to compress the air/fuel mixture. At high speed, the "ram" effect will make this act like a compression increase (air keeps rushing in after the piston starts coming up). At low speed, this will cause the piston to actually push some air/fuel mixture out of the cylinder, acting like a compression decrease.

HTH

EDIT - Merc, your faster than I am!!

Smokie
10-11-2004, 06:54 PM
Thank you gentleman I appreciate the responses, I completely understand how an open intake valve during piston up travel will reduce volume in cylinder and therefore less air = less compression. It is a little more difficult for me to understand how less air = more power.

However it is easier for me to understand how a longer duration of the exhaust valve during exhaust/intake stroke will help to push out more exhaust gases and allow a cleaner intake charge.