![]() |
#1
|
|||
|
|||
A resurrection: 2003 MM fix!
Hello:
Saw this on CL last year, I drive a MGM, this MM was being parted, but when I visited it I knew I had to step in. 200 mile tow, $1300 bucks and 131K on the clock. Would not run. broken control arms , seemingly no frame whack/damage. Allegedly has pullies and a Magnaflow exhaust, had a Lidio's tune but the PO took it off. 355 gears. (I'm thinking Mo's! for this time around.) Slowly I have started accumulating parts and pieces to get MM back on the road...early car around #300 on the build sheet....car is Single Stage black has been repainted a few times. So far: replaced:missing front sway bar, headrests, floor mats, LF fender, hood(from a MM), door (from a MM), rear sail panel trim interior piece, interior door panels, radio, Left side U/L control arms, fuel pump, fuel pump relay, battery, airbox, MAF, HVAC O-rings....now she starts and has a smooth idle. I have a damaged rear SB MARAUDER bumper cover I'm fixing, but what's on there now is a black CV cover from a junked taxi...still can read the numbers if you get real close, but this car is NOT FOR HIRE!!!! LOL...front bumper egg crate/ plastic things, CV tailights, MGM head lamps, turn signals....How quickly a $1300 car becomes a $3000 car. who cares? I now have a MM!!!!!!!!! I may have gone slightly OCD on a CL car. https://www.youtube.com/watch?v=wW9-63dA-8E On the agenda -I'm getting fuel level gauge code, fuel gauge does not work (new cheapo fuel pump issue?) maybe I'll swap the new fuel pump motor over to the guts/bracket/float sending unit of the old fuel pump, install inner fender liner, front bumper cover (MGM one for now, I didn't have the $600 to get a MM one, MGM one was $79 bucks), fix oil filter adapter leak,drivers side and pass rear window mechanisms... Stay tuned! advice will be sought at various times. image.jpg Last edited by Agent2006; 08-29-2018 at 05:24 PM. Reason: corrections |
#2
|
||||
|
||||
Your a true frankenstein. +1
Use "the right stuff" to seal both sides of the oil filter adapter gasket. P/N 70801 from felpro |
#3
|
|||
|
|||
You mean: The spray on "right stuff" from Home Depot, made by Dow Chemical? Thanks! I was going to put it on dry...best forum on the internet!
|
#4
|
||||
|
||||
I use Permatex RTV “Right Stuff” Your FLAPS should all carry it.
|
#5
|
||||
|
||||
Great to see one being saved! Wish more would!
|
#6
|
||||
|
||||
Keep us informed and post pics!
__________________
Righteous Indignation 03 300A 4055 of 7838 4054 of 7093 in Black. Born 8/23/02 Adopted in 1/15. |
#7
|
||||
|
||||
I have the 4 door panels off this exact car if you're interested, I also have a decent set of 03 Marauder OE headlights. shoot me a PM.
__________________
![]() |
#8
|
||||
|
||||
What crownvic97 said
|
#9
|
|||
|
|||
WTF?
For a few weeks I've investigated "no crank, no start" on this car, then today: --hooked a remote starter switch to two of the terminals of new starter I put on there. Just heard whirring. So the bendix is not kicking in? Then I tried the key. BINGO. Car immediately fired up and settled into a smooth idle/purr... BIFF: nobody can start this car but me? pix shortly. I'm putting the front end back together... https://www.youtube.com/watch?v=b-KGR9lV05I Last edited by Agent2006; 12-30-2018 at 06:30 PM. Reason: link |
#10
|
||||
|
||||
#11
|
|||
|
|||
Finally got the front end together, aftermarket parts (they don't fit too bad, considering)...I tried to hold out for OEM but like many tough guys: Marauders tend to die with their boots on, - the front end pieces are trashed. Got tired of waiting..header panel is from Taiwan Rock Auto was $137 shipped, front bumper cover was from Parts Train $433 shipped! lousy cell phone pic...
so: -control arms are replaced -fender/hood/grill/lights/drivers door are on to do: -fix oil filter housing gasket -low fuel light/gauge doesn't work -finish installing guts of drivers door -install interior door panels -test drive.... Last edited by Agent2006; 01-09-2019 at 07:01 PM. |
#12
|
||||
|
||||
Great progress! Keep it up!
|
#13
|
||||
|
||||
Good deal on the bumper! I luckily found one at the junk yard for $25 one day!
Sent from my iPhone using Tapatalk Pro |
#14
|
||||
|
||||
Well, that's a steal!
|
#15
|
||||
|
||||
Extremely impressed! Fantastic progress. More photos when weather and time permit please.
Also, what's next? Living vicariously through your build.
__________________
2003 300A Black, #4918 of 7838, 17,400 Miles Tune, KYB's, JLT, FlowMaster 42441, Res Delete, New BFG's, 8 coats of zymoil Titanium 2003 300B Silver Birch, #21 of 419, 29,800 miles Tune, JLT, FlowMaster 42441 Res Delete, New Nitto 235/255 Bigcarsforever dead peddle & custom SRP peddles, 5 coats Zymoil Titanium, Addco front and rear sway bars, KYBs, 1/2 inch coil cut, Sparts Watts link and Control Arms, Carfixer alignment. 2003 CV Sport Matador Red, 19,280 Miles, DD, Curless Full Service Royal flush, Marto Tune, 18 Chrome Wheels w 235/265 front/back Nitto tires, Monroe Severe Duty Shocks, Carfixer Alignment 2004 CV HPP Silver Birch, 93,000 miles. Son's DD, 18 Chrome Wheels w 235/265 front/back Nitto tires (thank you Lowdex!) |
![]() |
Currently Active Users Viewing This Thread: 1 (0 members and 1 guests) | |
Thread Tools | |
Display Modes | |
|
|
![]() |
||||
Thread | Thread Starter | Forum | Replies | Last Post |
Operation Trilogy Resurrection | Comin' in Hot | Community Discussion | 100 | 12-14-2018 06:23 AM |
Marauder Resurrection | golfmiser | Shop Talk | 24 | 10-16-2015 08:08 AM |
2003 COBRA RIMS ON MY 2003 MARAUDER | LFERRARA | Tires & Wheels | 11 | 12-10-2014 06:17 AM |
Resurrection Its Back | FastMerc | Buckeye Marauders | 14 | 04-19-2007 05:30 PM |
Which Will Be Rarer: 2003 Blue MM or 2003 Silver MM? | Zane | Community Discussion | 19 | 08-03-2003 09:42 PM |